|
|
Kleen All Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office
718-748-1550 Toll Free: (800) 537-9545. Fax: (718) 748-3425 |
Kleen All Plus Material Safety Data Sheet
IDENTITY: #330-333, Aluminum/Stainless Steel Cleaner/Brightener
SECTION I
|
Manufacturer
Name: Address Emergency Telephone
Number Telephone Number
For Information Date Prepared: Prepared by: |
Kleen All Plus 1-800-537-9545 1-800-537-9545 June 2006 Staff |
SECTION II -
HAZARDOUS INGREDIENTS IDENTITY INFORMATION
|
Hazardous
Components |
OSHA PEL |
ACGIH TLV |
OTHER LIMITS |
PERCENT
OPTIONAL |
|
*Phosphoric Acid
CAS# 7664-38-2 |
1 mg/m^3 |
1 mg/m^3 |
3 mg/m^3 |
(STEL) 10-30 |
|
***Dipropylene
Glycol Monomethyl Ether CAS# 34590-94-8 |
100 ppm |
100 ppm |
|
|
|
****Ammonium
Bifluoride CAS# 1341-49-7 |
2.5 mg/m3 |
|
|
|
Regulatory
Information – See Section IX
DOT
Shipping Classification: Corrosive liquid
Health Rating 3 Flammability 0 Reactivity 0
SECTION III -
PHYSICAL I CHEMICAL CHARACTERISTICS
|
Boiling Point 212 deg. F Vapor Pressure (mm
Hg)… NA Vapor Density
(air=1 )…>1 Solubility in
water…Complete Appearance and
Odor: Clear liquid, fruity odor |
Specific
Gravity.(H20=1) >1 Melting Point: NA Evaporation Rate…:
NA (Butyl Acetate=1) |
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point (Method
Used): None Flammable limits: LEL: NA UEL:
NA
Extinguishing Media:
See unusual fire and explosion hazards
Special Fire
Fighting Procedures: None
Unusual Fire and
Explosion Hazards: Although this product does not meet the parameters for
flammability, it may react with metals to liberate hydrogen, a flammable
gas. In this case, water spray may be
effective in absorbing gas..
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office 718-748-1550 Toll Free: (800) 537-9545. Fax:
(718) 748-3425 |
SECTION V #330-333 Page 2
Stability: Unstable
[ ] Stable [X]
Incompatibility
(materials to avoid): Avoid materials such as sulfides and sulfites, strong
bases. Avoid mixing with unknown
chemicals
Hazardous
Decomposition or Byproducts: None
Hazardous
Polymerization May occur [ ] Will
not occur [X]
Conditions to avoid: None
SECTION VI . Health Hazard Data
Route(s) of entry Inhalation? Yes Skin? Yes Ingestion? Yes
Health Hazards(Acute
and Chronic): Irritation to upper respiratory tract, eyes and skin, burns skin
and eyes, dermatitis. At 1 ppm, the
Federal Standard, phosphoric acid mist is irritating to unacclimated workers
but easily tolerated by acclimated workers.
Carcinogenicity: NTP?
No (ARC Monographs)? No OSHA
Regulated? No
Medical Conditions
Generally Aggravated by Exposure: Points of attack ore respiratory system,
lungs, eyes and skin.
Emergency and First
Aid Procedures: Eyes and skin – Flush with water and see physician. Ingestion – get immediate medical
attention. Inhalation – remove to fresh
air and perform artificial respiration.
If necessary, see physician.
SECTION VII . Precautions for Safe Handling and Use
Steps to Be Taken In
Case Material is Released or Spilled: Flush with water and soda ash.
Pick up with absorbent.
Waste Disposal
Method: According to federal, state and local authorities only.
Precautions For
Storing and Handling: Keep from freezing.
Other Precautions:
Do not contaminate with foreign chemicals.
SECTION VIII - Control Measures
Respiratory
Protection (Specify Type): When exposure limit is exceeded, use NIOSH approved
equipment with full face piece.
|
Ventilation |
Local Exhaust: |
Special: |
|
|
Mechanical: |
Other |
Protective
Gloves: Impervious
Eye Protection: Chemical
safety goggles. Eyewash should be
accessible.
Other Protective
Clothing or Equipment: Impervious
clothing.
Work Hygienic Practices:
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office 718-748-1550 Toll Free: (800) 537-9545. Fax:
(718) 748-3425 |
SECTION IX #330-333 Page 3
*Phosphoric acid is
subject to SARA section 311, 312 and 313.
It is classified as an Immediate Health Hazard. It may contain traces of listed chemicals
from
***Dipropylene Glycol Monomethyl Ether is
subject to SARA Section 311/312 as an immediate health hazard and a fire
hazard.
****Ammonium
Bifluoride is subject to state Right To Know regulations in MA and NJ, CA Prop.
65.