|
|
Kleen All Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office
718-748-1550 Toll Free: (800) 537-9545. Fax: (718) 748-3425 |
Kleen All Plus Material Safety Data Sheet
IDENTITY: #427n, Blanket and roller wash
SECTION I
|
Manufacturer
Name: Address Emergency
Telephone Number Telephone Number
For Information Date Prepared: Prepared by: |
Kleen All Plus 1-800-537-9545 1-800-537-9545 May 2006 Staff |
SECTION II -
HAZARDOUS INGREDIENTS IDENTITY INFORMATION
|
Hazardous
Components |
OSHA PEL |
ACGIH TLV |
OTHER LIMITS |
PERCENT
OPTIONAL |
|
*Light Aromatic
Solvent Naphtha CAS# 64742-95-6 |
*50ppm |
|
|
15 |
|
Aliphatic
Hydrocarbon CAS# 64747-48-9 |
100ppm |
100ppm |
|
|
*See
Section IX for explanation of 50 ppm calculation
Health Rating 2 Flammability 2 Reactivity 0
SECTION III -
PHYSICAL I CHEMICAL CHARACTERISTICS
|
Boiling Point 318 - 338 deg. F Vapor Pressure (mm
Hg)… 11 @ 100 deg. F. Vapor Density
(air=1 )…>4.1 – 4.3 Solubility in
water…Miscible .02% @ 77 deg F. Appearance and
Odor: Amber to clear liquid, aromatic hydrocarbon odor |
Specific
Gravity.(H20=1) <1 Melting Point: NA Evaporation Rate…:
<1 (Butyl Acetate=1) |
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point (Method Used): 108 deg F. Flammable
limits: LEL: 1.9 UEL: 12.6
Extinguishing Media: Water, fog, foam, dry chemical, carbon
dioxide and vaporizing liquid type extinguishing agents.
Special Fire Fighting Procedures: Do not enter confined fire space without
full bunker gear, NIOSH approved self contained
Unusual Fire and Explosion Hazards: Containers exposed to intense heat from
fires should be cooled with water to prevent vapor pressure buildup which could
cause container rupture. Containers
exposed to direct
|
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office 718-748-1550 Toll Free: (800) 537-9545. Fax:
(718) 748-3425 |
SECTION V #427n Page 2
Stability: Unstable
[ ] Stable [X]
Conditions to Avoid: None:
None
Incompatibility
(materials to avoid): Peroxide hazard on concentration; inhibitor has been
added to mitigate peroxide hazard.
Hazardous
Decomposition or Byproducts: Under fire conditions; Nitric acid, sulfuric acid,
strong oxidizers
Hazardous
Polymerization May occur [ ] Will
not occur [X]
SECTION VI . Health Hazard Data
Route(s) of entry Inhalation? Yes Skin? Yes Ingestion? Yes
Health Hazards(Acute
and Chronic): Prolonged or repeated exposure may cause drying or defatting of
skin. Slightly irritating to eyes but
does not injure eye tissue. Inhalation –
High vapor concentrations are irritating to the yes and respiratory tract and may
affect central nervous system. In
extreme cases unconsciousness or death may occur. Ingestion – Minimal toxicity. Small amounts aspirated into the respiratory
system during ingestion or vomiting may cause mild to severe pulmonary injury,
even death.
Carcinogenicity: NTP?
No (ARC Monographs)? No OSHA
Regulated? No
Medical Conditions
Generally Aggravated by Exposure: Pre-existing eye, skin, and respiratory
disorders.
Emergency and First
Aid Procedures: Eyes– Flush with water, and get medical attention. Skin – Flush with water, then use soap and
water. Ingestion – Do NOT
SECTION VII . Precautions for Safe Handling and Use
Steps to Be Taken In
Case Material is Released or Spilled: Eliminate sources of ignition.
Soak up with absorbent material and place in non-leaking containers for
disposal. If spill is in a public area,
advise authorities.
Waste Disposal
Method: Dispatch to an approved waste disposal facilities in conformation with federal,
state and local authorities.
Precautions For
Storing and Handling: “Empty” containers contain residue and can be
dangerous. Do not pressurize, cut, weld,
braze, solder, drill, grind, or expose such containers to heat, flame, sparks
or other sources of ignition. They may
explode and cause injury..
Other Precautions: Keep
containers closed when not in use. Do
not contaminate with foreign chemicals.
SECTION VIII - Control Measures
Respiratory
Protection (Specify Type): NIOSH/MSHA approved respirators if used in confined
space, or to prevent overexposure if TLV is present.
|
Ventilation |
Local Exhaust: |
Special: |
|
|
Mechanical: |
Other |
Protective
Gloves: Chemical resistant.
Eye Protection:
Goggles, face shield, or glasses to prevent splashing, with side shields.
Other Protective
Clothing or Equipment: Eye wash
and protective clothing.
Work Hygienic Practices:
|
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office 718-748-1550 Toll Free: (800) 537-9545. Fax:
(718) 748-3425 |
Section IX – Additional Information
*The light aromatic
solvent naptha contains:
Trimethyl Benzene
Based on the above
data, EXXON recommends 50 total hydrocarbon based on composition.
Section X – Regulatory Information
Clean Water Act/oil pollution act – The light aromatic solvent naptha is
classified as oil. Discharge or spills
which produce a visible sheen on either surface water, or in waterways/sewers
which lead to surface water, must be reported to the
SARA Title III:
Under Section 311/312 of the Superfund Amendments and Reauthorization
act, this product is classified into the following categories:
Section 313: This
product contains the following reportable ingredients:
1,2,4-Trimethylbenzene 95-63-6 4.8
Xylene 1330-20-7 0.50
Cumene 98-82-8 0.25