|
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF"
, . |
|
Manufacturer
Name: Address Emergency
Telephone Number Telephone Number
For Information Date Prepared: Prepared by: |
Kleen All Plus 476 68th
Street Brooklyn, NY 11220 1-800-537-9545 1-800-537-9545 February 2005 Staff |
SECTION II -
HAZARDOUS INGREDIENTS I IDENTITY INFORMATION
|
Hazardous
Components |
OSHA PEL |
ACGIH TLV |
OTHER LIMITS |
PERCENT
OPTIONAL |
|
d-Limonene CAS#
5989-27-5 |
Not listed |
Not listed |
|
|
|
*N-Methylpyrrolidone
CAS# 872-50-4 |
Not Established |
|
|
|
*N-Methylpyrrolidone
is subject to the reporting requirements of SARA Title III, Section 313.
DOT
Shipping Classification: Not regulated when shipped by ground in 55 gallon
drums or less
Health Rating 1
Flammability 2
Reactivity 0
Personal Protection B
SECTION III -
PHYSICAL I CHEMICAL CHARACTERISTICS
|
Boiling Point 310 deg. F Vapor Pressure (mm
Hg)… 1 mm @ 14 deg. C Vapor Density
(air=1 )… .012 Solubility in
water…miscible Volatile Organic
Compounds…< 5% Appearance and
Odor: Clear to slightly amber liquid, orange scent |
Specific
Gravity.(H20=1) 0.83 Melting Point: NA Evaporation Rate…:
<1 (Butyl Acetate=1) |
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point (Method
Used): 115 deg. F TCC
Flammable limits: LEL: 0.7 UEL: 6.1
Extinguishing Media:
Foam, carbon dioxide or dry chemical.
Avoid contact with water.
Special Fire
Fighting Procedures: Closed containers exposed to heat, but not burning, could
be suitably cooled with water.
Unusual Fire and
Explosion Hazards: None
|
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF"
, . |
Stability: Unstable
[ ] Stable [X]
Conditions to Avoid:
Avoid exposure to flames or excessive heat.
Incompatibility
(materials to avoid): Strong oxidizing agents, acids, D-limonene reacts
violently with iodine pentafluroide in tetra-fluoroethylene.
Hazardous
Decomposition or Byproducts: None
Hazardous
Polymerization May occur [ ] Will
not occur [X] Conditions to Avoid:
None
SECTION VI . Health Hazard Data
Route(s) of entry Inhalation? Yes Skin? Yes Ingestion? Yes
Health Hazards(Acute
and Chronic): Eyes – Vapors irritate mucous membranes and eyes – may cause
blurred vision. Prolonged contact may
cause photosensitivity. Skin contact
may cause moderate itching. Frequent
exposure may induce dermatitis. May be
moderate irritant to throat and respiratory passages by inhalation. Ingestion – unknown. N-Methylpyrrolidone – an experimental
teratogen. Experimental reproductive
effects. Mutation data reported.
Carcinogenicity: NTP?
No (ARC Monographs)? No OSHA
Regulated? No
Medical Conditions
Generally Aggravated by Exposure: None
Emergency and First
Aid Procedures: Eyes and skin – Flush with water. If irritation persists, see physician. Inhalation – remove to fresh air and consult a physician
immediately. Ingestion – administer
water to dilute and immediately induce vomiting. Consult a physician immediately.
SECTION VII . Precautions for Safe Handling and Use
Steps to Be Taken In
Case Material is Released or Spilled: No smoking! Small spills – wipe
up material with paper rags. DO NOT USE
CLAY. Place them in closed metal waste
container. Large spills – Do not hose
down drains. Use non-flammable
absorbent.
Waste Disposal Method:
May be incinerated or burned in a licensed facility according to federal, state
and local authorities.
Precautions For
Storing and Handling: Keep away from heat, acids and oxidizing agents. Store in tightly sealed, preferably full
containers.
Other Precautions:
Do not contaminate with unknown chemicals.
SECTION VIII - Control Measures
Respiratory
Protection (Specify Type): Local exhaust should be adequate. May use mechanical.
|
Ventilation |
Local Exhaust: Normal |
Special: |
|
|
Mechanical: |
Other |
Protective
Gloves: Impermeable gloves
Eye Protection:
Safety Glasses or face shield.
Other Protective
Clothing or Equipment: Eye wash
and shower stations should be
available.
Work Hygienic Practices: Wash thoroughly after handling. Launder contaminated clothing before
reuse.