|
|
Kleen All
Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office 718-748-1550 Toll Free: (800) 537-9545. Fax:
(718) 748-3425 |
Kleen All Plus Material Safety Data Sheet
IDENTITY: #8638 Enhance OV
SECTION I
|
Manufacturer
Name: Address Emergency
Telephone Number Telephone Number
For Information Date Prepared: Prepared by: |
Kleen All Plus 1-718-748-1550 1-718-748-1550 April 2006 Staff |
SECTION II -
HAZARDOUS INGREDIENTS IDENTITY INFORMATION
|
Hazardous
Components |
OSHA PEL |
ACGIH TLV |
OTHER LIMITS |
PERCENT OPTIONAL |
|
Synthetic
Isoparaffinic Hydrocarbon |
Exxon/Mobile
recommends an exposure limit of a TWA of 1200 mg/m3 (152 ppm) based on total
hydrocarbon |
|||
Health Rating 1 Flammability 2 Reactivity 0
Dot Shipping Classification:
In containers of 119 gallons capacity or less this product is not regulated by
DOT
SECTION III –
PHYSICAL/CHEMICAL CHARACTERISTICS
|
Boiling Point 424-484 deg. F Melting Point: NA Vapor Pressure (mm
hg) <0.1 @ 68 deg. F. Vapor Density (air=1
)… 5.9 Solubility in
water… Negligible |
Appearance and
Odor: Clear to slight yellow liquid, orange vanilla odor Specific
Gravity.(H20=1) .79 Evaporation Rate…:
< 0.01 (Butyl Acetate=1) |
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point (Method Used):
177 deg F Flammable limits: Not
Applicable LEL: 1.3 UEL 8.8
Extinguishing Media:
Foam, C02, dry chemical, water fog.
Special Fire
Fighting Procedures: Combustible liquid.
Material can accumulate static charges which can cause an incendiary
electrical discharge. Avoid spraying
water directly into containers due to danger of boil over.
Unusual Fire and
Explosion Hazards: Containers exposed to intense heat from fire should be cooled
with water to prevent vapor pressure build-up which could result in container
rupture. A volatile liquid, it gives off
invisible vapors. Either the liquid or
the vapors may settle in low areas or travel long distance along the ground or
surface to ignition sources where they may ignite or explode.
|
Kleen All Plus "ALL YOUR CLEANING SUPPLIES UNDER ONE ROOF", . Office
718-748-1550 Toll Free: (800) 537-9545. Fax: (718) 748-3425 |
SECTION V #127 Page 2
Stability: Unstable
[ ] Stable [X] Conditions to Avoid: None
Incompatibility
(materials to avoid): Strong oxidizing agents, Unknown chemicals
Hazardous
Decomposition or Byproducts: None
Hazardous
Polymerization May occur [ ] Will
not occur [X]
SECTION VI . Health Hazard Data
Route(s) of entry Inhalation? Yes Skin? Low toxicity Ingestion? Minimal toxicity
Health Hazards(Acute
and Chronic): May be eye irritant, but does not injure eye tissue. Skin – prolonged or repeated exposure may
result in dermatitis. Inhalation – high
vapor concentrations (>700 ppm) may be irritating to the nose, respiratory
tract, and may cause CNS depression, evidenced in giddiness, dizziness, nausea,
and death. Ingestion – small amounts
aspirated into the respiratory system during ingestion or vomiting may cause
mild to severe pulmonary injury, possibly progressing to death.
Carcinogenicity; NTP?
No (ARC
Monographs)? No OSHA Regulated? No
Medical Conditions Generally Aggravated by
Exposure: Preexisting eye,
skin and respiratory disorders may be aggravated by exposure to this product.
Emergency and First Aid Procedures:. Flush eyes and skin with water. If
Irritation of eyes, persists, see physician.
Inhalation – remove victim to fresh air and provide oxygen/artificial
respiration if needed; Get medical attention.
Ingestion – Do NOT induce
vomiting. If vomiting occurs
spontaneously, keep head below hips to prevent aspiration of liquid into lungs
. Call physician.
SECTION VII . Precautions for Safe Handling and Use
Steps to Be Taken In
Case Material is Released or Spilled: Keep source of ignition and hot metal surfaces away from spill. Dike and contain large spills. Small spills may be picked up with absorbent
and placed in non-leaking containers for disposal.
Waste Disposal
Method: Seal and label containers properly and dispatch to approved waste
disposal facility in accordance with federal, state and local regulations. Prevent spills from entering sewers, storm
drains and natural waterways..
Precautions For
Storing and Handling: Avoid installation of vapors. No smoking near this product. Remove saturated clothing and flush affected
areas.
Other Precautions:
Keep container closed when not In use.
Even empty containers may contain explosive vapors. Do not cut, drill, grind, weld or perform
similar operations on or near containers.
SECTION VIII - Control Measures
Respiratory
Protection (Specify Type): Local exhaust ventilation is recommended to control
process emissions near the source. If
TLV is exceeded, NIOSH/MSHA approved respirators may be necessary.
Protective Gloves: Chemical resistant
Eye Protection:
Safety glasses with side shields
Other Protective
Clothing or Equipment: Safety
shower, eye bath and washing facilities.
Work Hygienic Practices: